| 第 49 卷第 3 期 |  | Vol. 49 No. 3 | | 2019 年 6 月 | Jun 2019 |
|
所屬欄目：醫藥及中間體
連續液-液萃取法制備高含量液體姜辣素 |
| 凌 琳，李英奇，戴世杰，曾健青*
（湖南和廣生物科技有限公司，湖南 永州 425000） |
| 摘 要：以超臨界二氧化碳萃取所得的姜樹脂為原料，采用連續液-液萃取法進行分離提純，高效制備高含量液體姜辣素�？疾炝溯腿r(shí)間、溶劑與溶質質量比、萃取溶劑流量、萃取溫度等對產物姜辣素、6-姜酚含量及收率的影響。結果表明，以80%乙醇水溶液為溶劑，姜樹脂為溶質，溶劑與溶質的質量比為6∶1；正己烷為萃取溶劑，萃取溶劑流量為1.0 L·h-1，萃取溫度為30℃，萃取時間為3 h，此條件下萃取結果最好，可將姜辣素含量從50.29%提高至83.59%，對應6-姜酚的含量從34.77%提高到68.62%，姜辣素和6-姜酚的收率分別達90.96%和86.01%。 |
| 關鍵詞：姜辣素；6-姜酚；連續液-液萃取法；分離提純；姜樹脂 |
| 中圖分類號：R284.1 文獻標識碼：A 文章編號：1009-9212（2019）03-0016-05 |
|
| Preparation of High Content Liquid Gingerol by Continuous Liquid-liquid Extraction |
| LING Lin, LI Ying-qi, DAI Shi-jie, ZENG Jian-qing*
(Hunan Health-Guard Biotechnology Incorporated Company, Yongzhou 425000, China) |
| Abstract：Using ginger oleoresin extracted from ginger by supercritical carbon dioxide extraction method as the raw material, high content liquid gingerol was prepared efficiently through separation and purification by continuous liquid-liquid extraction. The effects of factors including extraction time, solvent mass ratio, extraction solvent flow rate and extraction temperature on the content and yield of gingerol were evaluated. The optimum conditions were obtained as followings: 80% ethanol solution was used as solvent; ginger oleoresin was used as solute; the mass ratio of solvent to solute was of 6; the extraction solvent flow rate was of 1.0 L·h-1 using nhexane as extraction solvent; extraction temperature was of 30℃; extraction time was of 3 h. Under these process parameters, the content of gingerol could be increased from 50.29% to 83.59%; meanwhile the content of 6-gingerol could be increased from 34.77% to 68.62%; the yield of gingerol and 6-gingerol could reach up to 90.96% and 86.01%, respectively. |
| Key words：gingerol; 6-gingerol; continuous liquid-liquid extraction; separation and purification; ginger oleoresin |
|
基金項目： 湖南省創(chuàng )新創(chuàng )業技術投資項目（2017GK5038），湖南省企業科技創(chuàng )新創(chuàng )業團隊項目（和廣生物現代萃取分離與應用科技創(chuàng )新創(chuàng )業團隊）。
|
作者簡介：凌 琳（1991-），女，湖南株洲人，碩士，研究方向：植物提取、分離純化與應用（E-mail：18874848142@163.com）。
|
聯 系 人：曾健青，研究員，博士，研究方向：超臨界流體技術研究與應用（E-mail：jackingzeng@vip.163.com）。
|
收稿日期： 2019-04-0
|
|